摘要: |
利用以炭纤维为载体的生物膜反应器处理酵母废水,通过逐步提高进料浓度的方式,对厌氧生物膜反应器处理高浓度有机废水的能力及反应器内微生物的多样性变化特征进行了探索。结果表明,当控制水力停留时间(HRT)为6 d,进料COD浓度由启动时2 798 mg/L分阶段提升至5 596和13 990 mg/L的过程中,相应的沼气容积产气率分别为0.06、0.14和0.37 L/(L·d),平均甲烷含量分别为57%、71%和74%,COD平均去除率分别为45%、64%和65%,反应器表现出了较强的抗有机负荷冲击能力。当进料COD浓度继续提高至22 980 mg/L,对应COD容积负荷达4.7 g/(L·d)时,COD去除率降至49%,但pH能维持在7.7,平均甲烷含量为66%,沼气容积产气率进一步上升到0.58 L/(L·d)。可见,过高的进料容积负荷虽然提高了容积产气率,但会造成沼气转化效率的下降。高通量测序结果表明,随着有机负荷的增加和运行时间的延长,反应器内微生物菌群逐渐稳定并演化成了以甲烷螺菌属(Methanospirillum)、甲烷鬃菌属(Methanosaeta)、甲烷杆菌属(Methanobacterium)为古菌代表和以食酸菌属(Acidovorax)、芽孢八叠球菌属(Sporosarcina)为细菌代表的优势菌属构成的沼气微生物菌群,优势菌属占总微生物数量的比例为58%。启动初期和稳定期的沼液中古菌、细菌所占比例分别为69.23%、30.77%和66.86%、33.14%;产甲烷类菌株在古菌菌群中的比例从起始阶段的33.11%提升到稳定阶段的76.70%,氢营养型产甲烷菌成为古菌群落结构中占绝对优势地位的类群(由起始阶段的24.67%升高到稳定阶段的60.13%)。 |
关键词: 酵母废水 沼气发酵 生物膜反应器 微生物群落结构 生物甲烷 |
DOI:10.11841/j.issn.1077-4333.2017.08.17 |
分类号: |
基金项目:国家自然科学基金项目(31370506);湖北省自然科学基金项目(2014CFB666);国家自然科学基金青年基金项目(31500422);三峡大学研究生科研创新基金项目(2015CX141) |
|
Study on fermentation characteristics of yeast wastewater treated by biofilm reactor |
YAO Yi1, LV Yucai1, LI Ning2, GUO Jinling1, TIAN Yihong1, GONG Dachun1
|
1.College of Biological and Pharmaceutical Sciences, China Three Gorges University, Yichang 443002, China;2.College of Hydraulic and Environmental Engineering, China Three Gorges University, Yichang 443002, China
|
Abstract: |
To explore the capability of anaerobic biofilm reactor to treat high concentration organic waste water and the variation of microbial diversity in the reactor,biofilm reactor with carbon fiber carrier was used to handle yeast waste water by gradually raising feeding concentration.Hydraulic retention time (HRT) was controlled to 6 d in this study.The results showed that:The volumetric efficiency of gas production increased from 0.06 to 0.14 and 0.37 L/(L·d);During the process of upgrading,the influent COD concentration was 2 798 mg/L at startup phase and increased to 5 596 and 13 990 mg/L;The average methane contents were 57%,71% and 74% respectively,and the average COD removal rate were 45%,64% and 65% respectively.The reactor displayed strong resistance capability to organic loading shocks.When influent COD concentration continued increasing to 22 980 mg/L and the corresponding COD volume loading was 4.70 g/(L·d),the COD removal rate reduced to 49%,and pH was remained at 7.7,the average methane content was 66% and the volumetric efficiency of gas production further increased to 0.58 L/(L·d).It was found that over feeding volume loading improved the volumetric efficiency of gas production,but also caused the decreasing of gas conversion efficiency.High-throughput sequencing results showed that marsh-microbes in the bio-reactor gradually stabilized with the organic loading increasing and the operation time elapsing.And the main archaea and bacteria of microbial community in the reactor were Methanospirillum,Methanosaeta,Methanobacterium and Acidovorax,Sporosarcina,respectively.The proportion of dominant microorganisms was 58%.The proportions of archaea and bacteria of marsh liquid in start and stable phase were 69.23%,30.77% and 66.86%,33.14%,respectively.The proportion of methanogens in archaea communities was raised from 33.11% (initial stage) to 76.70% (stable stage),and hydrogenotrophic methanogens became the dominant microorganism in archaea community which was increased from 24.67% (initial stage) to 60.13% (stable stage). |
Key words: yeast wastewater biogas fermentation biofilm reactor microbial community structure bio-methane |